CHLOROACETIC ACID

ICSC: 0235

CHLOROACETIC ACID
Chloroethanoic acid
Monochloroacetic acid
MCA
ClCH₂COOH
Molecular mass: 94.5
CAS # 79-11-8
RTECS # AF8575000
ICSC # 0235
UN # 1751
EC # 607-003-00-1

TYPES OF HAZARD/ EXPOSURE	ACUTE HAZARDS/ SYMPTOMS	PREVENTION	FIRST AID/ FIRE FIGHTING
FIRE	Combustible. Gives off irritating or toxic fumes (or gases) in a fire.	NO open flames.	Powder, alcohol-resistant foam, water spray, carbon dioxide.
EXPLOSION			In case of fire: keep drums, etc., cool by spraying with water.

EXPOSURE		AVOID ALL CONTACT!	IN ALL CASES CONSULT A DOCTOR!
INHALATION	Corrosive. Burning sensation. Cough. Laboured breathing. Sore throat. Symptoms may be delayed (see Notes).	Ventilation, local exhaust, or breathing protection.	Fresh air, rest. Half-upright position. Refer for medical attention.
SKIN	Corrosive. MAY BE ABSORBED! Redness. Pain. Blisters.	Protective gloves. Protective clothing.	Remove contaminated clothes. Rinse skin with plenty of water or shower. Refer for medical attention.
EYES	Corrosive. Redness. Pain. Severe deep burns.	Face shield.	First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then take to a doctor.
INGESTION	Corrosive. Abdominal cramps. Burning sensation. Collapse.	Do not eat, drink, or smoke during work.	Rinse mouth. Do NOT induce vomiting. Refer for medical attention.

SPILLAGE DISPOSAL

STORAGE

PACKAGING & LABELLING

Sweep spilled substance into containers. Wash away remainder with plenty of water (extra personal protection: P2 filter respirator for harmful particles).

Separated from strong oxidants, strong bases, food and feedstuffs. Dry.

Do not transport with food and feedstuffs.
T symbol
R: 25-34
S: 23-37-44
UN Hazard Class: 6.1
UN Subsidiary Risks: 8
UN Packing Group: II

SEE IMPORTANT INFORMATION ON BACK

ICSC: 0235

Prepared in the context of cooperation between the International Programme on Chemical Safety & the Commission of the European Communities © IPCS CEC 1993

International Chemical Safety Cards

CHLOROACETIC ACID

ICSC: 0235

I
M
P
O
R
T
A
N
T

D
A
T
A

PHYSICAL STATE; APPEARANCE:
COLOURLESS CRYSTALS , WITH PUNGENT ODOUR.

PHYSICAL DANGERS:

CHEMICAL DANGERS:
The substance decomposes on heating producing toxic and corrosive gases (hydrogen chloride, phosgene). The solution in water is a strong acid, it reacts violently with bases and is corrosive.

OCCUPATIONAL EXPOSURE LIMITS (OELs):
TLV not established.
PDK: 1 mg/m³ (USSR 1993).

ROUTES OF EXPOSURE:
The substance can be absorbed into the body by inhalation and through the skin and by ingestion.

INHALATION RISK:
A harmful contamination of the air will be reached rather slowly on evaporation of this substance at 20°C.

EFFECTS OF SHORT-TERM EXPOSURE:
Corrosive. The substance is corrosive to the eyes, the skin and the respiratory tract. Inhalation of aerosol may cause lung oedema (see Notes). The substance may cause effects on the cardiovascular system, central nervous system and kidneys , resulting in cardiac disorders, convulsions, and kidney impairment. The effects may be delayed. Medical observation is indicated.

EFFECTS OF LONG-TERM OR REPEATED EXPOSURE:

PHYSICAL
PROPERTIES

Boiling point: 189°C
Melting point: about 57°C
Relative density (water = 1): 1.6
Solubility in water, g/100 ml at 20°C: 85
Vapour pressure, kPa at 43°C: 0.13

Relative vapour density (air = 1): 3.3
Relative density of the vapour/air-mixture at 20°C (air = 1): 1.00
Flash point: 126°C
Explosive limits, vol% in air: 8.0-?

ENVIRONMENTAL
DATA

NOTES

The symptoms of lung oedema often do not become manifest until a few hours have passed and they are aggravated by physical effort. Rest and medical observation are therefore essential. Immediate administration of an appropriate spray, by a doctor or a person authorized by him/her, should be considered. The symptoms of the central nervous system effects, cardiac and renal failure do not become manifest until a few hours have passed. Specific treatment is necessary in case of poisoning with this substance; the appropriate means with instructions must be available. Melting point of alpha form = 63°C, beta form = 56°C, gamma form = 53°C.

Transport Emergency Card: TEC (R)-57
NFPA Code: H 3; F 1; R 0;

ADDITIONAL INFORMATION

ICSC: 0235	CHLOROACETIC ACID
© IPCS, CEC, 1993

IMPORTANT LEGAL NOTICE:

Neither the CEC or the IPCS nor any person acting on behalf of the CEC or the IPCS is responsible for the use which might be made of this information. This card contains the collective views of the IPCS Peer Review Committee and may not reflect in all cases all the detailed requirements included in national legislation on the subject. The user should verify compliance of the cards with the relevant legislation in the country of use.