International Chemical Safety Cards

cis-2-BUTENE ICSC: 0397
cis-2-BUTENE
2-Butene, (Z)-
cis-Dimethylethylene
b-cis-Butylene
(cylinder)
C4H8/CH3-HC=CH-CH3
Molecular mass: 56.1
CAS # 590-18-1

ICSC # 0397
UN # 1012
EC # 601-012-00-4
TYPES OF
HAZARD/
EXPOSURE 		ACUTE HAZARDS/
SYMPTOMS 		PREVENTION FIRST AID/
FIRE FIGHTING
FIRE Extremely flammable.
NO open flames, NO sparks, and NO smoking.
Shut off supply; if not possible and no risk to surroundings, let the fire burn itself out; in other cases extinguish with water spray.
EXPLOSION Gas/air mixtures are explosive.
Closed system, ventilation, explosion-proof electrical equipment and lighting. Prevent build-up of electrostatic charges (e.g., by grounding) if in liquid state. Use non-sparking handtools. Flame arrester to prevent flash-back from burner to cylinder.
In case of fire: keep cylinder cool by spraying with water. Combat fire from a sheltered position.
 
EXPOSURE


INHALATION Dizziness. Unconsciousness.
Ventilation, local exhaust, or breathing protection.
Fresh air, rest. Refer for medical attention.
SKIN ON CONTACT WITH LIQUID: FROSTBITE.
Cold-insulating gloves.
ON FROSTBITE: rinse with plenty of water, do NOT remove clothes. Refer for medical attention.
EYES See Skin.
Face shield.
First rinse with plenty of water for several minutes (remove contact lenses if easily possible), then take to a doctor.
INGESTION
Do not eat, drink, or smoke during work.

SPILLAGE DISPOSAL STORAGE PACKAGING & LABELLING
Evacuate danger area! Consult an expert! Ventilation. NEVER direct water jet on liquid (extra personal protection chemical suit including self-contained breathing apparatus).
Fireproof. Store outside or in a separate well-ventilated building. Cool.

F+ symbol
R: 12
S: (2-)9-16-33
Note: C
UN Hazard Class: 2.1
SEE IMPORTANT INFORMATION ON BACK
ICSC: 0397 Prepared in the context of cooperation between the International Programme on Chemical Safety & the Commission of the European Communities © IPCS CEC 1996

International Chemical Safety Cards

cis-2-BUTENE ICSC: 0397

I

M

P

O

R

T

A

N

T



D

A

T

A
PHYSICAL STATE; APPEARANCE:
COLOURLESS COMPRESSED LIQUEFIED GAS.

PHYSICAL DANGERS:
The gas is heavier than air and may travel along the ground; distant ignition possible, and may accumulate in low ceiling spaces causing deficiency of oxygen. As a result of flow, agitation, etc., electrostatic charges can be generated.

CHEMICAL DANGERS:


OCCUPATIONAL EXPOSURE LIMITS (OELs):
TLV not established.


ROUTES OF EXPOSURE:
The substance can be absorbed into the body by inhalation.

INHALATION RISK:
On loss of containment this liquid evaporates very quickly causing supersaturation of the air with serious risk of suffocation when in confined areas.

EFFECTS OF SHORT-TERM EXPOSURE:
Rapid evaporation of the liquid may cause frostbite. The substance may cause effects on the central nervous system. Exposure may result in unconsciousness.


PHYSICAL
PROPERTIES
 Boiling point: 4°C
Melting point: -139°C
Relative density (water = 1): 0.6
Solubility in water: none
Vapour pressure, kPa at 21°C: 188		 Relative vapour density (air = 1): 1.9
Flash point: Flammable gas
Auto-ignition temperature: 324°C
Explosive limits, vol% in air: 1.7-9.0
Octanol/water partition coefficient as log Pow: 2.33
ENVIRONMENTAL
DATA
N O T E S
High concentrations in the air cause a deficiency of oxygen with the risk of unconsciousness or death. Check oxygen content before entering area. Turn leaking cylinder with the leak up to prevent escape of gas in liquid state. The recommendations on this Card also apply to trans-2-butene (ICSC # 0398).
Transport Emergency Card: TEC (R)-500
NFPA Code: H1; F4; R0;
ADDITIONAL INFORMATION


ICSC: 0397 cis-2-BUTENE
© IPCS, CEC, 1996
IMPORTANT LEGAL NOTICE: Neither the CEC or the IPCS nor any person acting on behalf of the CEC or the IPCS is responsible for the use which might be made of this information. This card contains the collective views of the IPCS Peer Review Committee and may not reflect in all cases all the detailed requirements included in national legislation on the subject. The user should verify compliance of the cards with the relevant legislation in the country of use.